Analysis and design improvement of MCP-PMT high-voltage breakdown fault based on high voltage module power supply
-
摘要: 为克服MCP-PMT传统高压供电设备体积大、便携性差的问题，采用了基于小型化高压模块的高压供电方式。该系统在实际使用过程中发生了一起MCP-PMT高压击穿故障。详细分析了该系统的故障原因，将问题定位为MCP-PMT内部真空度下降导致的耐压性能下降，同时还发现了导致故障发生的诱因是高压模块在加电时刻存在的高压过冲现象。针对高压模块的过冲问题，本文提出了较为巧妙的设计改进方法并取得了良好的效果，进一步提高了MCP-PMT系统的工程应用可靠性。Abstract: To overcome the large size and poor portability of MCP-PMT traditional high-voltage power supply equipment, a high-voltage power supply mode based on miniaturized high-voltage module is adopted. During the practical use of the system, a high-voltage breakdown fault of MCP-PMT occurred. In this paper, the fault causes of the system are analyzed in detail, and the problem is identified as the decline of withstand voltage performance caused by the decline of internal vacuum of MCP-PMT, and it is also found that the high voltage overshoot of the high voltage module at the time of power-up is the cause of this fault. Aiming at the overshoot problem of high-voltage module, this paper puts forward a more ingenious design improvement method and achieves good results, which further improves the engineering application reliability of MCP-PMT system.
-
Key words:
- MCP-PMT /
- high-voltage module /
- high-voltage breakdown
-
图 5 C-M级（a）和M-M级（b）在耐压试验的不同时刻出现的高压击穿波形
Figure 5. High-voltage breakdown waveform at different times of voltage withstand test
图 6 故障PMT在耐压试验中出现的连续击穿波形
Figure 6. Continuous breakdown waveforms of faulty PMT in withstand voltage test
图 7 加电初始时刻各极高压变化情况
Figure 7. Changes of each extreme high-voltage at the initial time of power on
图 8 故障PMT在加电时刻的高压击穿波形
Figure 8. High-voltage breakdown waveforms of faulty PMT at power on time
-
[1] 滨松光子学株式会社. 光电倍增管基础及应用——光探测器开拓光子学的未来[M]. 滨松: 滨松光子学株式会社, 1995: 43-44Hamamatsu Photonics Corporation. Foundation and application of photomultiplier tube[M]. Hamamatsu: Hamamatsu Photonics Corporation, 1995: 43-44 [2] Lehmann A, Böhm M, Miehling D, et al. Recent progress with microchannel-plate PMTs[J]. Nuclear Instruments and Methods in Physics Research Section A: Accelerators, Spectrometers, Detectors and Associated Equipment, 2020, 925: 161821. [3] Ren Ling, Sun Jianning, Si Shuguang, et al. Study on the improvement of the 20-inch microchannel plate photomultiplier tubes for neutrino detector[J]. Nuclear Instruments and Methods in Physics Research Section A: Accelerators, Spectrometers, Detectors and Associated Equipment, 2020, 977: 164333. doi: 10.1016/j.nima.2020.164333 [4] 赵天池. 传感器和探测器的物理原理和应用[M]. 北京: 科学出版社, 2008: 554-556Zhao Tianchi. Physical principles and applications of sensors and detectors[M]. Beijing: Science Press, 2008: 554-556 [5] 赵文锦. 光电倍增管的技术发展状态[J]. 光电子技术, 2011, 31(3):145-148. (Zhao Wenjin. Developments in technology of photomultipliers[J]. Optoelectronic Technology, 2011, 31(3): 145-148Zhao Wenjin. Developments in technology of photomultipliers[J]. Optoelectronic Technology, 2011, 31(3): 145-148 [6] Moshkunov S I, Khomich V Y, Shershunova E A. A high-voltage switching power supply for cold plasma jets[J]. Technical Physics Letters, 2019, 45(2): 93-95. doi: 10.1134/S1063785019020123 [7] Wu Hao, Xiao Linyan. Design of high efficiency dc switching power supply based on soft switch[J]. Journal of Physics: Conference Series, 2019, 1345: 052077. doi: 10.1088/1742-6596/1345/5/052077 [8] 张波涛, 彭旭升, 王城, 等. 用于脉冲中子探测器的小型化高压模块性能研究[J]. 强激光与粒子束, 2019, 31:035005. (Zhang Botao, Peng Xusheng, Wang Cheng, et al. Performance study of miniaturized high-voltage module for pulsed neutron detector[J]. High Power Laser and Particle Beams, 2019, 31: 035005 doi: 10.11884/HPLPB201931.180288Zhang Botao, Peng Xusheng, Wang Cheng, et al. Performance study of miniaturized high-voltage module for pulsed neutron detector[J]. High Power Laser and Particle Beams, 2019, 31: 035005 doi: 10.11884/HPLPB201931.180288 [9] 邵涛, 严萍, 张适昌, 等. 纳秒脉冲气体放电机理探讨[J]. 强激光与粒子束, 2008, 20(11):1928-1932. (Shao Tao, Yan Ping, Zhang Shichang, et al. Review on nanosecond-pulse discharge mechanism in gases[J]. High Power Laser and Particle Beams, 2008, 20(11): 1928-1932Shao Tao, Yan Ping, Zhang Shichang, et al. Review on nanosecond-pulse discharge mechanism in gases[J]. High Power Laser and Particle Beams, 2008, 20(11): 1928-1932 -
下载:
点击查看大图
计量
- 文章访问数: 885
- HTML全文浏览量: 309
- PDF下载量: 58
- 被引次数: 0
