航空发动机电子控制器的高强辐射场干扰及防护

肖国松; 刘家豪; 马振洋; 史春蕾

doi:10.11884/HPLPB202436.230320

航空发动机电子控制器的高强辐射场干扰及防护

doi: 10.11884/HPLPB202436.230320

肖国松^2,,
刘家豪^{1, 2,},
马振洋^2, ,,
史春蕾^{1, 2}

1.
中国民航大学安全科学与工程学院，天津 300300
2.
中国民航大学民航航空器适航审定技术重点实验室，天津 300300

基金项目: 天津市科技局自然基金多元基金项目重点项目（21JCZDJC00860）

详细信息

作者简介:
肖国松，xiaoguosong@sina.cn

通讯作者:
马振洋，zyma@cauc.edu.cn。

中图分类号: V216.5
计量
- 文章访问数: 141
- HTML全文浏览量: 53
- PDF下载量: 52
- 被引次数: 0
出版历程
- 收稿日期: 2023-09-18
- 修回日期: 2023-12-13
- 录用日期: 2023-12-29
- 网络出版日期: 2023-12-28
- 刊出日期: 2024-02-29

HIRF interference research and protection of aircraft engine electronic controller

Xiao Guosong^2
,,
Liu Jiahao^{1, 2
,},
Ma Zhenyang^{2
, ,},
Shi Chunlei^{1, 2}

1.
College of Safety Science and Engineering, Civil Aviation University of China, Tianjin 300300, China
2.
Key Laboratory of Civil Aircraft Airworthiness Technology, Civil Aviation University of China, Tianjin 300300, China

摘要

摘要: 针对航空发动机电子控制器（EEC）易受高强辐射场（HIRF）干扰问题，以ZF-M600型EEC为研究对象，通过三维电磁仿真软件CST对EEC建模并进行平面波辐照仿真，模拟HIRF对EEC的干扰效应，仿真结果表明，HIRF可以通过孔缝耦合进入EEC内部并在腔体内部产生谐振，谐振频率处电场强度显著增加。依据RTCA DO-160G在400 MHz~4 GHz开展EEC辐射敏感度试验，试验结果表明：EEC失效频点为2.40 GHz和3.48 GHz，敏感模块为模拟量输入输出模块，敏感现象为模拟量数据丢失。EEC失效频点与谐振频率接近, 说明EEC失效与腔体谐振有关，在EEC内部贴装吸波材料并进行仿真，分析吸波材料的放置方式和厚度对EEC谐振电磁干扰强度的影响，仿真结果表明，贴装吸波材料可以有效抑制谐振电磁干扰。
- 发动机电子控制器 /
- 高强辐射场 /
- 辐射敏感度 /
- 谐振频率 /
- 电磁防护
Abstract: To solve the problem that the aviation Engine Electronic Controller (EEC) is easily disturbed by high-intensity radiation field (HIRF) interference, the plane wave irradiation simulation is performed to simulate the interference effect of HIRF on the EEC through the software CST for the modeling of the EEC. The simulation results show that HIRF can be coupled into the EEC and the electric field strength increases significantly at the resonance frequency. Conducting EEC radiated susceptibility tests at 400 MHz-4 GHz, the test results show that the EEC failure frequency points are 2.40 GHz and 3.84 GHz, the susceptive module is the analog input and output module, The EEC failure frequency is close to the resonance frequency, and the EEC failure is related to the cavity resonance. The wave-absorbing material is mounted inside the EEC and simulation is carried out, and the simulation results show that the wave-absorbing material can effectively suppress the resonance electromagnetic interference, and the results of the study can provide a theoretical basis and reference for the HIRF protection of the EEC.
- engine electronic controller /
- high-intensity radiation field /
- radiation sensitivity /
- resonant frequency /
- electromagnetic protection

HTML全文

图 1 发动机电子控制器

Figure 1. Aircraft Electronic Engine Controller

下载: 全尺寸图片幻灯片

图 2 EEC仿真模型

Figure 2. Simulation model of the EEC

下载: 全尺寸图片幻灯片

图 3 平面波辐照仿真

Figure 3. Plane wave irradiation simulation

下载: 全尺寸图片幻灯片

图 4 EEC平面波辐照仿真结果

Figure 4. Plane wave irradiation simulation results of the EEC

下载: 全尺寸图片幻灯片

图 5 试验环境及设备布置

Figure 5. Radiation sensitivity test environment

下载: 全尺寸图片幻灯片

图 6 EEC辐射敏感度试验原理图

Figure 6. Schematic diagram of EEC radiation sensitivity

下载: 全尺寸图片幻灯片

图 7 EEC试验前调试

Figure 7. Debugging before EEC test

下载: 全尺寸图片幻灯片

图 8 模拟量信号试验结果

Figure 8. Analog output module test results

下载: 全尺寸图片幻灯片

图 9 吸波材料的贴装位置

Figure 9. Placement position of absorbing material

下载: 全尺寸图片幻灯片

图 10 吸波材料防护效果

Figure 10. Protective effect of the absorbing material

下载: 全尺寸图片幻灯片

表 1 EEC外壳结构及材料参数

Table 1. Shell structure and material of the EEC

structure	material	electrical conductivity/(s·m⁻¹)	relative permeability/(h·m⁻¹)	relative permittivity
housings	aluminium	3.56	1	1.5
power switch	aluminium	3.56	1	1.5
aviation plug housings	aluminum alloy	3.45	1	1.0
aviation plug pins	brass	1.59	1	1.0
status indicator	air	−	−	1.0
screws	iron	1.04	1	10.0
copper of pcbs	copper	5.80	1	1.5
medium of pcbs	FR4	5.96	1	5.0

下载: 导出CSV

表 2 测试设备型号及功能

Table 2. Test equipment type

test equipment	model	function
oscilloscope	DSO1022A	monitor digital output
power analyzer	PA2203A	monitor analogue output
computer	G510	monitor serial output
signal generator	UTG2062A	provide input signal
power supply	E3631A	power supply
impedance stabilized network	DN-LISN160	prevent interference

下载: 导出CSV

表 3 COM1数据输出协议

Table 3. COM1 data output protocol

statement structure	output data	byte	offset
statement header	0×48	1	0
statement header	0×59	1	1
statement header	0×53	1	2
statement id number	0×02	1	3
sentence body	cycle count	2	4
checksum	—	4	32

下载: 导出CSV

表 4 F类设备辐射敏感度试验场强

Table 4. Class F equipment radiation sensitivity test field

frequency/GHz	field strength/(V·m⁻¹)	sampling rate	sampling interval/MHz	stirring speed/(r·min⁻¹)
0.4~1.0	350	60	10	4
1.0~2.0	1000	100	10	2
2.0~4.0	1500	200	10	2

下载: 导出CSV

表 5 EEC谐振频率与失效频点

Table 5. EEC resonant frequency and failure frequency

mode	calculated resonant resonant frequency/GHz	simulation results/GHz	cutoff frequency/GHz
f₁₁₀	2.72	2.62	2.40
f₀₂₁	3.68	3.55	3.48

下载: 导出CSV

参考文献(31)

[1]	潘晓东, 魏光辉, 万浩江, 等. 电子设备电磁辐射敏感度测试相关问题研究[J]. 强激光与粒子束, 2020, 32:073002 doi: 10.11884/HPLPB202032.200088 Pan Xiaodong, Wei Guanghui, Wan Haojiang, et al. Research on several test issues of electromagnetic radiationsusceptibility for electronic equipment[J]. High Power Laser and Particle Beams, 2020, 32: 073002 doi: 10.11884/HPLPB202032.200088
[2]	马振洋, 左晶, 史春蕾, 等. 机载电子设备屏蔽效能测试与优化[J]. 航空学报, 2020, 41:323538 Ma Zhenyang, Zuo Jing, Shi Chunlei, et al. Test and optimizati on of shield effectiveness for airborne electronic equipment[J]. Acta Aeronautica et Astronautica Sinica, 2020, 41: 323538
[3]	Somolinos D R, Gallardo B P, Estevez J C, et al. Shielding effectiveness measurement of an UAV simplified demonstrator through low-level swept field (LLSF) test[J]. IEEE Transactions on Electromagnetic Compatibility, 2022, 64(5): 1665-1673. doi: 10.1109/TEMC.2022.3202636
[4]	Tortorich R P, Morell W, Reiner E, et al. A study on the radiated susceptibility of printed circuit boards and the effects of via fencing[J]. Electronics, 2021, 10: 539. doi: 10.3390/electronics10050539
[5]	Tang Shiping, Mao Junfa. A quantification control method of electromagnetic environmental effects for complex systems[J]. Journal of Electromagnetic Waves and Applications, 2021, 35(2): 245-261. doi: 10.1080/09205071.2020.1832149
[6]	赵治国, 郑浩月. 典型电子设备强电磁安全效应试验研究[J]. 通信技术, 2019, 52(8):2008-2013 Zhao Zhiguo, Zheng Haoyue. Experimental exploration on high EM safety effect of typical electronic equipment[J]. Communications Technology, 2019, 52(8): 2008-2013
[7]	Dunkin E L, Duggan T J, Noyce R P. Hazards of electromagnetic radiation to ordnance (HERO) instrumentation developments for high intensity radiated field (HIRF) testing of aircraft[C]//Proceedings of 2019 ESA Workshop on Aerospace EMC. 2019: 1-6.
[8]	刘勇, 马跃进, 司晓亮, 等. 基于高强度辐射场的低电平扫频场试验方法研究[J]. 微波学报, 2020, 36(3):20-25 Liu Yong, Ma Yuejin, Si Xiaoliang, et al. Research on low level swept field test method based on high intensity radiation field[J]. Journal of Microwaves, 2020, 36(3): 20-25
[9]	Ückerseifer J, Gronwald F. Numerical and experimental analysis of non-coaxial DCI-excitations as HIRF-replacement in automotive immunity testing[C]//Proceedings of 2020 International Symposium on Electromagnetic Compatibility-EMC EUROPE. 2020: 1-6.
[10]	Sun Jiangning, Pan Xiaodong, Lu Xinfu, et al. Unshielded two-wire circuit systems under weak unbalance for high-intensity radiated field radiated susceptibility by double bulk current injection[J]. Electronics, 2022, 11: 2175. doi: 10.3390/electronics11142175
[11]	李琛, 文彬鹤, 左伟, 等. 带数字电子备份的发动机控制系统设计与验证[J/OL]. 航空动力学报, (2023-01-04)[2023-02-10].https://doi.org/10.13224/j.cnki.jasp.20220602 Li Chen, Wen Binhe, Zuo Wei, et al. Design and verification of engine control system with digital electronic backup[J/OL]. Journal of Aerospace Power, (2023-01-04)[2023-02-10].https://doi.org/10.13224/j.cnki.jasp.20220602
[12]	Montazeri-Gh M, Abyaneh S. Real-time simulation of a turbo-shaft engine's electronic control unit[J]. Mechanics & Industry, 2017, 18: 503.
[13]	何锋, 周璇, 赵长啸, 等. 航空电子系统机载网络实时性能评价技术[J]. 北京航空航天大学学报, 2020, 46(4):651-665 He Feng, Zhou Xuan, Zhao Changxiao, et al. Real-time performance evaluation technology of airborne network for avionics system[J]. Journal of Beijing University of Aeronautics and Astronautics, 2020, 46(4): 651-665
[14]	Liang Tao, Xie Yanzhao. Determining incidence and polarization of electromagnetic field for maximal/minimal coupling to transmission line system[J]. IEEE Microwave and Wireless Components Letters, 2020, 30(11): 1021-1024. doi: 10.1109/LMWC.2020.3021695
[15]	郭晓涛, 何昭, 王少华, 等. 电磁混响室场均匀性评定方法的实验研究[J]. 北京邮电大学学报, 2017, 40(4):86-90 Guo Xiaotao, He Zhao, Wang Shaohua, et al. Experiment on the field uniformity validation methods of reverberation chamber[J]. Journal of Beijing University of Posts and Telecommunications, 2017, 40(4): 86-90
[16]	Gifuni A, Gradoni G, Serra R, et al. On the improvement of shielding effectiveness measurements of materials and gaskets in reverberation chambers[J]. IEEE Transactions on Electromagnetic Compatibility, 2022, 64(5): 1653-1664. doi: 10.1109/TEMC.2022.3193191
[17]	肖培, 李佳维, 张超, 等. 双层屏蔽腔内线缆负载电磁耦合的EMT分析方法[J]. 微波学报, 2021, 37(5):52-57 Xiao Pei, Li Jiawei, Zhang Chao, et al. An EMT analysis method for calculating the electromagnetic coupling of transmission line inside a double-layer cavity-time performance evaluation technology of airborne network for avionics system[J]. Journal of Microwaves, 2021, 37(5): 52-57
[18]	Zhou Jincheng, Wang Xuetian. Fast prediction of the shielding effectiveness of heterotypic enclosures based on EMT theory[J]. International Journal of RF and Microwave Computer-Aided Engineering, 2022, 32: e23463.
[19]	郝建红, 蒋璐行, 范杰清, 等. 内置介质板的开孔箱体屏蔽效能电磁拓扑模型[J]. 电工技术学报, 2017, 32(9):101-111 Hao Jianhong, Jiang Luxing, Fan Jieqing, et al. Electromagnetic topology model for the shielding effectiveness of an apertured enclosure with a lossy dielectric layer[J]. Transactions of China Electrotechnical Society, 2017, 32(9): 101-111
[20]	Sun Jian, Gong Yanfei, Jiang Luhang. An improved model for the analysis of the shielding performance of an apertured enclosure based on EMT theory and BLT equation[J]. Journal of Electromagnetic Waves and Applications, 2022, 36(2): 246-260. doi: 10.1080/09205071.2021.1961614
[21]	Yan Liping, Zhang Xindan, Zhao Xiang, et al. A fast and efficient analytical modeling approach for external electromagnetic field coupling to transmission lines in a metallic enclosure[J]. IEEE Access, 2018, 6: 50272-50277. doi: 10.1109/ACCESS.2018.2867686
[22]	Ye Zhihong, Lu Changchang, Zhang Yu. Coupling analysis of penetrated wire connecting two electronic devices using a time domain hybrid method[J]. Microwave and Optical Technology Letters, 2021, 63(9): 2359-2363. doi: 10.1002/mop.32916
[23]	RTCA Inc. Environmental conditions and test proceduresfor airborne equipment[R]. RTCA/DO-160G, Washing: RTCA Inc, 2010.
[24]	Basyigit I B, Dogan H, Helhel S. The effect of aperture shape, angle of incidence and polarization on shielding effectiveness of metallic enclosures[J]. Journal of Microwave Power and Electromagnetic Energy, 2019, 53(2): 115-127. doi: 10.1080/08327823.2019.1607496
[25]	Xie Penghao, Yuan Jiansheng. Simulation analysis of electromagnetic coupling law of one typical electronic circuit box body[J]. The Journal of Engineering, 2017, 2017(14): 2695-2698. doi: 10.1049/joe.2017.0834
[26]	谭志良, 胡小锋, 毕军建, 等. 电磁脉冲防护理论与技术[M]. 北京: 国防工业出版社, 2013: 54-60 Tan Zhiliang, Hu Xiaofeng, Bi Junjian, et al. Electromagnetic pulse protection theory and technololgy[M]. Beijing: National Defense Industry Press, 2013: 54-60
[27]	邹澍, 周晓萍. 电磁兼容原理、技术和应用[M]. 北京: 清华大学出版社, 2007: 176-177 Zou Shu, Zhou Xiaoping. Principle technology and application of electromagnetic compatibility[M]. Beijing: Tsinghua University Press, 2007: 176-177
[28]	曾美玲, 蔡金良, 易早, 等. 孔缝对金属腔体强电磁脉冲耦合特性影响研究[J]. 强激光与粒子束, 2021, 33:043004 doi: 10.11884/HPLPB202133.200336 Zeng Meiling, Cai Jinliang, Yi Zao, et al. Effect of aperture on shielding performance of metal cavity under excitation of high-intensity electromagnetic pulse[J]. High Power Laser and Particle Beams, 2021, 33: 043004 doi: 10.11884/HPLPB202133.200336
[29]	赵翔, 茹梦圆, 闫丽萍, 等. 电磁混响室搅拌方式研究综述[J]. 强激光与粒子束, 2020, 32:063001 doi: 10.11884/HPLPB202032.200079 Zhao Xiang, Ru Mengyuan, Yan Liping, et al. A review of research on stirring methods of electromagnetic reverberation chamber[J]. High Power Laser and Particle Beams, 2020, 32: 063001 doi: 10.11884/HPLPB202032.200079
[30]	李小沙. 发动机电子控制器EEC技术手册[EB/OL]. 北京: 北京卓枫科技有限公司, 2019. [2023-11-06] Li Xiaoshao. Engine electronic controller EEC use and maintenance manual[EB/OL]. Beijing: Beijing Zhuofeng Technology, 2019. [2023-11-06]
[31]	陈生. 吸波材料抑制孔腔谐振研究[D]. 西安: 西安电子科技大学, 2008 Chen Sheng. Study on suppression of aperture-cavity resonance by means of absorbing materials[D]. Xi’an: Xidian University, 2008