Research on cable strong electromagnetic pulse coupling and protection simulation of vehicle engine mangement system
-
摘要: 强电磁脉冲可通过外部线缆耦合进入车辆发动机管理系统(EMS)内，造成发动机管理系统设备干扰甚至损伤，电磁防护组件可为车辆EMS防护设计提供支撑。以车辆EMS为研究对象，综合考虑EMS设备及其外部连接线缆，建立EMS设备电磁仿真模型，对不同长度线缆的端口耦合特性及EMS金属壳体表面感应电流进行了仿真研究。基于防护电路仿真，设计了一种应用于车辆EMS设备的电磁防护组件。仿真结果表明，该防护组件能将5 kV的电磁脉冲限制在最高峰值幅度为18 V以内，防护效能达到48 dB，将其加装于EMS线缆接口处可有效提高强电磁环境下的可靠性，对于车辆平台控制系统的电磁防护设计具有一定的参考意义。Abstract: Strong electromagnetic pulse can be coupled into vehicle engine management system (EMS) through external cables, causing interference and even damage to EMS equipment. Electromagnetic protection components can provide support for vehicle EMS protection design. This article takes vehicle EMS as the research object, comprehensively considers EMS equipment and its external connecting cables, establishes an electromagnetic simulation model of EMS equipment, and conducts simulation research on the port coupling characteristics of cables of different lengths and the induced current on the surface of EMS metal shell. Based on protective circuit simulation, an electromagnetic protection component applied to vehicle EMS equipment was designed. The simulation results show that the protection component can limit the 5 kV electromagnetic pulse to the maximum peak amplitude of 18 V, and the protection efficiency reaches 48 dB. Adding the protection component to the EMS cable interface can effectively improve the reliability in strong electromagnetic environment, which has certain reference significance for the electromagnetic protection design of the vehicle platform control system.
-
Key words:
- electromagnetic pulse /
- vehicle /
- protection device /
- electromagnetic protection /
- cable coupling
-
图 4 调制高斯脉冲信号激励时线缆端口耦合电压波形
Figure 4. Coupling voltage waveforms of cable port when excited by modulated Gaussian pulse signal
图 5 线缆L1末端沿z方向增加时两端负载情况
Figure 5. Load situation at both ends of cable L1 as it increases in the z-direction
图 6 线缆L1始端沿z方向增加时线缆端口耦合电压波形
Figure 6. Coupling voltage waveform of the cable port when the starting end of cable L1 increases in the z-direction
表 1 单芯线L1坐标点设置
Table 1. Coordinate point setting of single core line L1
point x/mm y/mm z/mm N1 63 −220 320 N2 63 −236 320 N3 166 −234 316 N4 200 −269 189 N5 180 −455 306 N6 278 −518 345 N7 304 −657 498 N8 429 −678 562 N9 508 −685 587 N10 616 −689 590 N11 616 −684 590 
下载: 导出CSV
表 2 单芯线L2坐标点设置
Table 2. Coordinate point setting of single core line L2
point x/mm y/mm z/mm N13 679 −610 719 N14 677 −456 719 N15 715 −339 712 N16 779 392 712
下载: 导出CSV
表 3 延长单芯线L1坐标点设置
Table 3. Coordinate point setting of extended single core line L1
point x/mm y/mm z/mm N1 63 −220 356 N2 63 −236 356 N3 63 −236 320 N4 166 −234 316 N5 200 −269 189 N6 180 −455 306 N7 278 −518 345 N8 304 −657 498 N9 429 −678 562 N10 508 −685 587 N11 616 −689 590 N12 616 −684 590
下载: 导出CSV
表 4 延长单芯线L2坐标点设置
Table 4. Coordinate point setting of extended single core line L2
point x/mm y/mm z/mm N13 679 −610 719 N14 677 −456 719 N15 715 −339 712 N16 779 392 712
下载: 导出CSV
-
[1] Radasky W A, Baum C E, Wik M W. Introduction to the special issue on high-power electromagnetics (HPEM) and intentional electromagnetic interference (IEMI)[J]. IEEE Transactions on Electromagnetic Compatibility, 2004, 46(3): 314-321. doi: 10.1109/TEMC.2004.831899 [2] 李名杰, 刘进. 电子装备面临的强电磁脉冲环境分析[J]. 装备环境工程, 2012, 9(2):69-73Li Mingjie, Liu Jin. Environmental analysis of high power EMP on electronic equipment[J]. Equipment Environmental Engineering, 2012, 9(2): 69-73 [3] Savage E, Radasky W. Overview of the threat of IEMI (intentional electromagnetic interference)[C]//Proceedings of 2012 IEEE International Symposium on Electromagnetic Compatibility. 2012: 317-322. [4] 蔡金良, 孙晓颖, 赵晓晖. 考虑复杂金属设备的车辆发动机舱电磁环境效应分析[J]. 吉林大学学报(工学版), 2016, 46(4):1360-1367Cai Jinliang, Sun Xiaoying, Zhao Xiaohui. Electromagnetic environment effects for automotive engine block with complex metallic equipments[J]. Journal of Jilin University (Engineering and Technology Edition), 2016, 46(4): 1360-1367 [5] 郑浩月, 贺志昂, 宋滔, 等. 车辆平台电磁安全威胁量化分析[J]. 通信技术, 2019, 52(2):460-465Zheng Haoyue, He Zhiang, Song Tao, et al. Quantitative analysis of electromagnetic safety threats on vehicle platforms[J]. Communications Technology, 2019, 52(2): 460-465 [6] 王震, 蔡金良, 秦风, 等. 汽车发动机转速传感器瞬变脉冲敏感性研究[J]. 强激光与粒子束, 2020, 32:083003 doi: 10.11884/HPLPB202032.200120Wang Zhen, Cai Jinliang, Qin Feng, et al. Susceptibility of automotive engine speed sensor to transient electromagnetic pulse[J]. High Power Laser and Particle Beams, 2020, 32: 083003 doi: 10.11884/HPLPB202032.200120 [7] 孙晓颖, 王震, 杨锦鹏, 等. 基于贝叶斯网络的电子节气门电磁敏感度评估[J]. 吉林大学学报(工学版), 2018, 48(1):281-289Sun Xiaoying, Wang Zhen, Yang Jinpeng, et al. Electromagnetic susceptibility assessment of electronic throttle based on Bayesian network[J]. Journal of Jilin University (Engineering and Technology Edition), 2018, 48(1): 281-289 [8] 李慧梅, 唐彦峰, 刘祥凯, 等. 电磁脉冲武器对车辆装备的损伤效应研究[J]. 装备环境工程, 2010, 7(3):31-34,55Li Huimei, Tang Yanfeng, Liu Xiangkai, et al. Study of destructive effects of electromagnetic pulse weapon on vehicle[J]. Equipment Environmental Engineering, 2010, 7(3): 31-34,55 [9] 秦风, 蔡金良, 曹学军, 等. 车辆强电磁脉冲环境适应性研究[J]. 强激光与粒子束, 2019, 31:103203 doi: 10.11884/HPLPB201931.190233Qin Feng, Cai Jinliang, Cao Xuejun, et al. Investigation on the adaptability of vehicle in high-intensity electromagnetic pulse environment[J]. High Power Laser and Particle Beams, 2019, 31: 103203 doi: 10.11884/HPLPB201931.190233 [10] Yang Shenghui, Tang Yanfeng, Liu Xiangkai, et al. Study on effects of high-altitude electromagnetic pulse to engine electronic control system[J]. Advanced Materials Research, 443/444: 894-898. [11] Hobbins K A W. EMP and transient suppressed mains filters[C]//Proceedings of the Seventh International Conference on Electromagnetic Compatibility. 1990. [12] 张希军, 杨洁, 张庆海. 瞬态电压抑制器在快上升沿电磁脉冲作用下的瞬态响应[J]. 高电压技术, 2012, 38(9):2242-2247Zhang Xijun, Yang Jie, Zhang Qinghai. Transient response of transient voltage suppressor device under EMP with fast rise time[J]. High Voltage Engineering, 2012, 38(9): 2242-2247 [13] 王磊, 周彪, 邓世雄, 等. 半导体电磁防护限幅器的发展[J]. 安全与电磁兼容, 2023(3):17-23Wang Lei, Zhou Biao, Deng Shixiong, et al. Progress on semiconductor limiters for electromagnetic defense[J]. Safety & EMC, 2023(3): 17-23 [14] 赵展, 尚逸帆, 赵启龙, 等. 滤波电路的电磁脉冲防护效应研究[J]. 航天电子对抗, 2020, 36(5):28-33 doi: 10.3969/j.issn.1673-2421.2020.05.008Zhao Zhan, Shang Yifan, Zhao Qilong, et al. Study on the protection of filter circuit against electromagnetic pulse[J]. Aerospace Electronic Warfare, 2020, 36(5): 28-33 doi: 10.3969/j.issn.1673-2421.2020.05.008 [15] 谢斌, 刘洁, 王波, 等. 强电磁脉冲防护技术研究[J]. 火控雷达技术, 2020, 49(2):111-115Xie Bin, Liu Jie, Wang Bo, et al. Research on strong electromagnetic pulse protection technology[J]. Fire Control Radar Technology, 2020, 49(2): 111-115 -
点击查看大图
计量
- 文章访问数: 149
- HTML全文浏览量: 65
- PDF下载量: 43
- 被引次数: 0
